功率型 厚膜 无感 电阻器 Power type Thick film Non inductive Resistor
l 安装在散热器，于 25℃时，额定功率达 35 瓦 ；在不使用散热片，25℃常温下，额定功率是 2.5 瓦
Installed on the radiator, with a rated power of 35 watts at 25 ℃; The rated power is 2.5 watts at room temperature of 25 ℃ without using heat sinks
l TO-220 功率型封装
TO-220 power type package
l 只用一颗螺丝，便可以安装于散热器上
With just one screw, it can be installed on the radiator
l 导电部分和金属底板绝缘，高绝缘度
The conductive part is insulated from the metal substrate, with high insulation level
l 保护性高的模压塑胶封外盒，且易于安装
Highly protective molded plastic outer box, and easy to install
l 无感设计 Sensorless design
射频功率放大器、缓冲电路、交换式电源供应、自动化控制器、不间断电源、电压调节、低能量脉冲载入、 UPS 等
RF power amplifier, buffer circuit, switched power supply, automation controller, uninterruptible power supply, voltage regulation, low-energy pulse loading, UPS，etc
|
1 |
铜散热片 |
Radiator Fin |
|
2 |
氧化铝基板 |
Alumina Substrate |
|
|
|
|
|
3 |
电阻层 |
Resistor Layer |
|
4 |
铜脚 |
Copper Lead |
|
|
|
|
|
5 |
模压封装 |
Molding |
|
|
|
|
©2025 V1.0
|
|
功率型 厚膜 无感 |
电阻器 |
Power type |
Thick film Non inductive Resistor |
|
|
|||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
|
测试项目 |
|
|
基本要求 |
|
|
|
|
|
测试方法 |
|
|
|||
|
|
Test project |
|
Basic Requirements |
|
|
|
|
Test Method |
|
|
|||||
|
|
短时间过负荷 |
|
|
|
|
|
2 倍额定功率，但不超过最大耐压的 1.5 倍，连续 5 秒钟 |
|
|
||||||
|
|
Short term overload |
|
|
△R±0.3% |
|
2 times the rated power, but not exceeding 1.5 times the |
|
|
|||||||
|
|
|
|
|
|
|
maximum withstand voltage, for 5 consecutive seconds |
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
|
负载寿命 |
|
|
△R±1.0% |
|
|
|
|
额定功率下 2000 小时 |
|
|
||||
|
|
Load Life |
|
|
|
|
|
|
2000 hours at rated power |
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
40±2℃、90～95%湿度下，在最大工作电压下维持 1000 小 |
|
|
|||||
|
|
耐湿测试 |
|
|
△R±0.5% |
|
时（1.5 小时“开”，0.5 小时“关”） |
|
|
|||||||
|
|
Humidity test |
|
|
|
|
|
Maintain 1000 hours at maximum operating voltage at 40 ±2 ℃ |
|
|
||||||
|
|
|
|
|
|
|
|
|
and 90-95% humidity (1.5 hours "on", 0.5 hours "off") |
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
焊接附著性 |
|
90%以上覆盖新锡 |
|
|
|
|
245±5℃持续 3 秒 |
|
|
|||||
|
|
Solderability |
|
Over 90% coverage of new tin |
|
245 ± 5 ℃ for 3 seconds |
|
|
||||||||
|
|
热冲击测试 |
|
|
△R±0.3% |
|
|
|
|
-65℃～﹢150℃，100 次循环 |
|
|
||||
|
|
Thermal Shock |
|
|
|
|
|
|
65 ℃~+150 ℃, 100 cycles |
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
引线强度 |
|
|
△R±0.2% |
|
|
|
|
（拉力测试）2.4 牛顿 |
|
|
||||
|
|
Lead strength |
|
|
|
|
|
|
(Tensile test) 2.4 Newtons |
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
高频震动 |
|
|
△R±0.2% |
|
|
|
|
|
20 公克震动 |
|
|
|||
|
|
High-frequency vibration |
|
|
|
|
|
|
20 grams of vibration |
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
|
绝缘强度 |
|
|
△R±0.15% |
|
|
|
|
1800V AC，60 秒 |
|
|
||||
|
|
Dielectric Strength |
|
|
|
|
|
|
1800V AC，60 seconds |
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
温度循环 |
|
|
ΔR±0.3% |
|
|
|
|
-65°C~+150°C，1000 次循环 |
|
|
||||
|
|
Temperature Cycling |
|
|
|
|
|
|
-65°C~+150°C, 1000 cycles |
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
型号 |
|
|
|
阻值范围 Resistance Range |
|
|
温度系数 |
|
|
|||||
|
|
Type |
|
±0.5% |
|
±1% |
|
|
|
±5% |
|
TCR（PPM/℃） |
|
|
||
|
|
|
|
/ |
|
|
|
≥0.1Ω～1Ω |
|
|
±300 |
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
/ |
|
|
|
≥1Ω～5Ω |
|
|
±100 |
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
±200 |
|
|
|
|
RTP35 |
|
|
|
|
≥5Ω～10Ω |
|
|
|
|
|||||
|
|
|
|
|
|
|
|
±300 |
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
±50 |
|
|
|
|
|
|
|
|
|
≥10Ω～100KΩ |
|
|
±100 |
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
±200 |
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
最大工作电压 Maximum operating voltage |
|
|
350VDC |
|
|
|||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
耐电压 Voltage endurance |
|
|
|
|
|
1800VAC |
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
绝缘电阻 Insulation resistance |
|
|
|
|
|
10GΩ min |
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
工作温度范围 Working temperature range |
|
|
- 55 ° C～+150 ° C |
|
|
|||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
©2025 V1.0
|
功率型 厚膜 无感 电阻器 |
Power type |
Thick film Non inductive Resistor |
|||
|
|
|
|
|
|
|
|
产品类型 |
|
功率 |
|
阻值 |
精度 |
|
Product type |
|
Power |
|
Resistance |
Accuracy |
|
RTP |
|
35 Watts |
|
3R9=3.9Ω |
D：±0.5% |
|
|
|
|
|
10R=10Ω |
F：±1% |
|
|
|
|
|
20K=20KΩ |
J：±5% |
|
|
|
|
|
|
|
